On Air Now

Listen Now

Weather

clear-day
83°
Chance of T-storms
H 91° L 71°
  • clear-day
    83°
    Current Conditions
    Chance of T-storms. H 91° L 71°
  • partly-cloudy-tstorms-day
    91°
    Today
    Chance of T-storms. H 91° L 71°
  • partly-cloudy-tstorms-day
    91°
    Tomorrow
    Chance of T-storms. H 91° L 71°
Listen
Pause
Error

News on-demand

00:00 | 00:00

Listen
Pause
Error

Traffic on-demand

00:00 | 00:00

Listen
Pause
Error

Weather on-demand

00:00 | 00:00

Local Govt & Politics
AJC EXCLUSIVE: Wall collapse exposed larger problem on I-75 lanes
Close

AJC EXCLUSIVE: Wall collapse exposed larger problem on I-75 lanes

GDOT says it's not sure if the collapse will delay the opening of the lanes.

AJC EXCLUSIVE: Wall collapse exposed larger problem on I-75 lanes

The recent collapse of a wall along an unfinished stretch of I-75 has prompted more extensive repairs and could delay the opening of 30 miles of toll lanes in Cobb and Cherokee counties, documents exclusively obtained by The Atlanta Journal-Constitution show.

An engineer’s report shows design and installation problems likely led to the collapse of the wall along the lanes near Windy Hill Road in June. But the problem may not be limited to the section that collapsed, and workers must now fix other walls along the Northwest Corridor Express Lanes.

The report also found the recent incident wasn’t the first sign of trouble. Another section of the same wall collapsed in July 2017, but that incident did not prompt a full investigation.

The Atlanta Journal-Constitution
Construction workers look over a section of the Northwest Corridor Express Lanes project on Interstate 75 South close to Windy Hill Road, near where a wall collapsed recently in Cobb County. Curtis Compton/ccompton@ajc.com
Close

AJC EXCLUSIVE: Wall collapse exposed larger problem on I-75 lanes

Photo Credit: The Atlanta Journal-Constitution
Construction workers look over a section of the Northwest Corridor Express Lanes project on Interstate 75 South close to Windy Hill Road, near where a wall collapsed recently in Cobb County. Curtis Compton/ccompton@ajc.com

The Georgia Department of Transportation did take steps to address the problem last year. But the full extent of the problem was not discovered until this year’s collapse prompted the agency and the project’s general contractor to seek an independent engineering firm to determine the cause of the wall collapse.

It’s unclear how long the repairs will take and when the new lanes will open. GDOT spokeswoman Natalie Dale said that if the lanes open by the end of September the project would still be on schedule.

However, GDOT could offer no timetable for completion of the $834 million project Monday. The agency had been planning to open the lanes by the end of August.

Dale said wall repairs aren’t the only factor in the schedule. Paving, striping, equipment testing and safety training all must be finished before the lanes open to the public.

“We won’t open the system until there is a safe and complete system for motorists, so the opening may be in the fall,” Dale said. “We have not yet set a groundbreaking date.”

A delay would be bad news for motorists seeking relief on a stretch of highway traveled by more than 300,000 vehicles a day.

When they open, the Northwest Corridor Express Lanes will allow motorists to drive along at speeds of 45 mph or more – if they’re willing to pay a toll of 10 cents to 90 cents a mile. They’re part of a planned 120-mile network of toll lanes – some of them already open – that GDOT says will help ease metro Atlanta’s awful traffic.

Construction of the Northwest Corridor has been hindered before. Last year’s collapse of I-85 in Buckhead prompted a halt to construction on I-75 as state officials sought to manage the resulting traffic nightmare. GDOT estimated that set back construction of the new I-75 lanes by up to six weeks.

‘The failure was localized’

Then in June, a section of wall collapsed near Windy Hill Road. The lanes are not yet open to traffic, and no one was injured in the incident.

The wall that collapsed was a facade wall in front of a sturdier retaining wall. The walls are connected by a series of large “soil nails” – reinforcing bars driven through the walls and into the soil. The crushed stone used as fill between the walls spilled out onto the unfinished lanes when the facade wall collapsed.

Afterward, general contractor Northwest Express Roadbuilders asked the engineering firm Wiss, Janney, Elstner Associates (WJE) to investigate.

WJE’s July 26 report, obtained by the AJC through an Open Records Act request, concluded that the primary cause of the collapse was the inadequate design of the system connecting the facade wall to the retaining wall. Installation of tie rods at excessive angles also may have contributed, the report found.

Ken Golski, corporate counsel for the company that designed the wall, Reinforced Earth Company, said other reviews of this year’s incident are ongoing and point to other causes. He said he could not elaborate.

“I feel very confident in our product and in our design,” Golski said.

The general contractor, Northwest Express Roadbuilders, could not immediately be reached for comment.

Channel 2 Action News
According to the WSB 24-hour Traffic Center, a wall collapsed along an unfinished portion of the Northwest Corridor Express Lanes project.
Close

BREAKING: Wall collapses along Northwest Corridor Express Lanes project

Photo Credit: Channel 2 Action News
According to the WSB 24-hour Traffic Center, a wall collapsed along an unfinished portion of the Northwest Corridor Express Lanes project.

WJE’s report also disclosed the previous incident from 2017, when a section of the same wall collapsed. Although “a full forensic investigation” was not done, a “non-conformance review” found evidence similar to those discovered after this year’s incident, the report found. Those included fractured or bent soil nails.

Last year’s incident prompted GDOT to suspend work on the walls. It increased inspection of walls built afterward, the report found. But the portion of wall that collapsed this year had already been built.

In written responses to AJC questions, GDOT said the agency and Northwest Express Roadbuilders also inspected the wall sections that had already been built. It said the contractor “concluded the failure was localized, and a repair procedure was recommended and implemented” by the contractor.

“The assessment recommended increased inspection for the remaining similar walls, which GDOT had no reason to believe was not the appropriate action at that time,” GDOT said.

The agency noted that “over 85 percent of the soil nail walls were completed without incident when the first failure occurred in July 2017,” including the section that failed this year.

Now that the problem has been discovered, WJE recommended retrofitting similarly constructed retaining walls along the Northwest Corridor with new soil nails to sufficiently anchor the facade wall.

GDOT said only 14 of the 69 retaining walls along the 30-mile corridor are similar to the wall that collapsed – about 1.75 miles of walls. Northwest Express Roadbuilders has told GDOT it will complete the repairs later this month.

The agency said that – under the terms of its contract – it’s the contractor’s responsibility to repair the walls and bear the cost.

It’s too soon to tell whether GDOT will penalize Northwest Express Roadbuilders or Reinforced Earth Company, officials said.

“GDOT reserves the right to ensure all concerns are addressed and the project is being delivered appropriately,” it said.

Northwest Corridor problems

Previously: In June a section of wall collapsed on a stretch of the lanes near Windy Hill Road.

What’s new: An engineer’s report found design and installation problems likely led to the collapse. The problem may not be limited to the wall that collapsed.

What’s next: The contractor is fixing the walls, but the problem could delay the opening of the new lanes.

Read More

News

  • A New Jersey man died early Saturday in a fireworks explosion in Jersey City, authorities said. According to witnesses, the victim, who has not been identified, was struck in the neck with fireworks shortly before 1 a.m., NJ.com reported. The explosion took place outside the Booker T. Washington housing complex, the website reported. Attempts to revive the man were unsuccessful, and he was pronounced dead at an area hospital. In 2017, New Jersey lawmakers legalized the use of certain fireworks, including poppers, sparklers and other non-aerial items, The Associated Press reported. According to NJ.com, a city task force was created after social media videos showed men conducting shootouts involving Roman candles, which are illegal in New Jersey.
  • A motorcyclist was thrown from their bike and killed Saturday morning after rear-ending an SUV on I-20 in Atlanta, police said. The crash occurred about 1:30 a.m. in the eastbound lanes near Hamilton E. Holmes Drive. Speed appears to have played a role in the deadly wreck, investigators said. “The preliminary investigation indicates an SUV was entering onto I-20 and observed a motorcycle approaching from behind at a high rate of speed,” Atlanta police said in a statement. “The motorist stated they attempted to avoid the motorcycle. However, the motorcycle struck the rear of the SUV, causing the motorcyclist to be ejected.” Read more on this story on ajc.com.
  • An Arizona woman fell to her death Friday at Grand Canyon National Park as she attempted to take photographs, park officials said. Maria A. Salgado Lopez, 59, of Scottsdale, was hiking off-trail when she fell off the edge of Mather Point, park officials said in a news release. Rangers received a call about 12:35 p.m. When they arrived, rangers found Lopez about 100 feet below the rim, KNXV reported. An investigation is being conducted by the National Park Service and the Coconino County Medical Examiner’s Office, KTVK reported. No additional information was available. In its release, park officials reminded visitors to follow safety guidelines. “Grand Canyon National Park staff encourage all visitors to have a safe visit this holiday weekend by staying on designated trails and walkways, always keeping a safe distance from the edge of the rim, and staying behind railings and fences at overlooks,” the park said in its release.
  • People aren’t the only ones feeling cooped up during the coronavirus pandemic. A wayward pet chicken hitched a ride with a Texas woman and her son to a Jiffy Lube on Wednesday, surprising everyone -- including the technicians performing an oil change. Tiffany Travis, of Pearland, was returning a dog and its crate to her neighbor, Laurie Fowler, KSAT reported. As Travis left, Fowler’s pet chicken, Maggie, jumped into the back of Travis’ truck, the television station reported. “Jury is still out if she flew into (the) bed or wheel well. Forensic Ring evidence is hazy,” Travis told KSAT. Travis and her son left and drove three miles to a Jiffy Lube for an oil change. When she started to pay for the service, she noticed a commotion. “My kids and I were in my husband’s truck, masked up COVID-style,” Travis told the television station. “When we were leaving the bay, because I was still in driver seat the entire time, we handed the staff my credit card through a cracked window and heard a commotion.” That’s when Travis saw a Jiffy Lube employee chasing after Maggie, finally catching the bird as it ran around one of the service bays. “Ma’am, is this your chicken? It just fell out of your truck,” the employee asked. “At first I was very confused,” Travis told KSAT. “Then it dawned on me. ‘Yes, yes that is my chicken.‘” “The JiffyLube staff [was] already cracking up. They all got out their phones and took pictures.” Oil’s well that ends well, even for the chicken. Maggie was unhurt, except perhaps for some ruffled feathers. “The entire experience was like a scripted sitcom and brought much-needed humor to what has been a rough few months for our family and well, humanity,” Travis told KSAT. “We all could use some laughter right about now. Thank God for funny chickens.”
  • Two boys magnet fishing reeled in an explosive find, a rusted old hand grenade. Lari Tammiviuori and Viljami Juutilainen made the discovery while fishing Thursday in Lake Vesijarvi in Lahti, Finland, YLE reported. 'We carried it to the shore with our hands, but then didn't touch it again when we found out what it was,' Tammivuori said.  The boys have gone magnet fishing frequently this summer, pulling in scrap metal, bottle caps and nails. They called police who arrived and disposed of the grenade.  The age and condition of the explosive have not been released.  Mother Maarit Juutilainen thought her son's magnet fishing hobby was harmless. “Now you kind of get scared of what they might find,” she said. “But we won’t allow the boys to continue fishing scrap from there.”
  • A 13-foot tall metal giraffe sculpture was stolen from out front of a St. Louis brewery and its owner is offering a $1,000 reward to get it back. “With all the bad going on in the world, you try to find things that make you smile,” Civil Life Brewing Company owner Jake Hafner told the St. Louis Post-Dispatch. “And the giraffe was one of those things.” Hafner bought the sculpture for $1,800 last year to lift employees' spirits after a plan to expand the brewery fizzled. The giraffe was added to a display that already included two large dinosaurs. Hafner took down a fence around the animal art in March.  “I thought, ‘nobody is going to take a 13-foot giraffe,’” Hafner said. “Famous last words.” Surveillance video from the brewery shows a white box truck pull up June 25 and minutes later the truck and giraffe are gone. The theft has been reported to police.  It would have likely taken at least two people to move the cumbersome, 160-pound sculpture.  Hafner is offering $1,000 reward for the giraffe’s return. He will also donate $1,000 to Northside Community Housing, an affordable housing group.